Question: Can Hay Get Too Dry To Bale?

Can hay be too dry to bale?

To make good hay, enough moisture must be present to keep all the leaves intact.

Too dry, and they shatter and fall off during the baling process.

Too wet, and hay will heat and mold.

In some situations, eight to 15 percent moisture is much too dry; the leaf quality will be lost..

Can hay get rained on?

Rained-on hay can be a suitable forage, especially for horses prone to laminitis. Forage quality tends to be retained if: The rain occurs soon after cutting when the forage has had little time to dry.

Is it worth wrapping dry hay?

Wrapping dry hay allows farmers to protect feed from the weather without building more structures. … Some farmers believe that more layers, up to six, are well worth the extra cost. A thicker barrier is more dependable than a thin one, but more costly.

What happens to hay when it gets wet before baling?

If hard pounding rains occur, leaves can be broken off, which will also lead to dry matter losses and a drop in quality. Sometimes, rain will not reduce hay quality significantly if the hay has adequate time to dry and cure prior to baling. The only way to know for sure, though, is to test the hay.

How long should hay dry before baling?

about three daysTime your mowing around the most reliable weather forecast you can find. It basically takes about three days of good weather to cure hay. This can be a challenge in late May or early June. A good strategy is to mow just before or right after a rain, because of the likelihood of good weather for the next few days.

What happens if you bale hay too early?

There is more moisture on the inside of the stem that’s not being measured. A day or two later, that moisture will migrate to the outside of the stem, raise the moisture content in the bale and heating, mould formation and heat damage to the protein can occur.

At what temperature does hay spontaneously combust?

130 degrees FahrenheitWhen hay’s internal temperature rises above 130 degrees Fahrenheit (55 degrees Celsius), a chemical reaction begins to produce flammable gas that can ignite if the temperature goes high enough. Fire is possible in hay that’s loose, in small or large bales or stacks, and stored inside or outside.

What moisture is dry hay?

The moisture content of standing hay varies from 65-85%. Hay destined for small square bales needs to be dried below 15% (85% dry matter) before baling for horses, to reduce the chance of dust. The majority of hay is air dried in the field over a 3 to 5-day period.

How soon can you feed hay after baling?

6 weeksHaylage needs to ferment, so it should not be fed straight after being baled and wrapped. The amount of time it takes to ‘cure’ is variable depending on the moisture and WSC content of the grass when it was wrapped, but a good guide is 6 weeks.

How do you check hay moisture before baling?

Breaking stems in half or twisting them in a circular motion to see if the stems break cleanly will give farmers the go-ahead to bale. “If all the stems break and crack that’s an indication that the hay is cured and then you can rely on the moisture test that you’re getting from the probe,” Yaremcio said.

At what temperature does hay mold?

Wet bales are at risk for combustion, store appropriately and check temperatures. Anything above 170°F is high risk. Mold may produce mycotoxins, so roll out and let animals select good portions of moldy bales.

How do you make hay dry faster?

Make A Wide Windrow Swath width is an easy adjustment that has a big impact on drying time. Lay the crop as wide as practical. Do not cut hay into a tight windrow. A wider swath will dry faster, because more drying area of the hay is exposed to sun and wind.

Does hay moisture increase after baling?

When hay is baled, it should not be higher than 18 to 22 percent moisture. At higher levels of moisture, bales lose large amounts of dry matter (Figure 1) caused by excessive heating and molding (Figure 2). In severe cases, spontaneous combustion is possible.

How can I dry hay fast?

Another method Kaatz suggests for making hay dry faster is to use a tedder. A tedder, which works especially well with grasses, will fluff the windrow or swath and allow air to flow through it more easily. The additional air dries the hay faster, but Kaatz advises not to use a tedder on partially dried alfalfa.